Data Search by General Subjects
IEAGHG Special: Conbustion Workshop on Oxyfuel, Addressing SO2, SO3, Hg and Corrosion Issues
IEAGHG Special: Conbustion Workshop on Oxyfuel, Addressing SO2, SO3, Hg and Corrosion Issues
Revision Date: 8/6/2015
Tags: 221118 - Other Electric Power , Oxycombustor, Mercury, SO2, SO3, Corrosion, Combustion, Optimizing
Mercury Removal Options Webinar - Hot Topic Hour July 23, 2015
A high level discussion of new developments over the last few months and updating of a Route Map and Summary of the issues and options. There is a program based on parametric testing resulting in the best choices for mercury reduction.
Revision Date: 7/23/2015
Tags: 221112 - Fossil Fuel 化石燃料, Mercury, Mercury Removal
Corrosion Studies on GeoBrom® HG520 Partial Immersion Study
Brominated derivative products for mercury control… There was little to no corrosion observed on these coupons in the vapor space. Visually, all corrosion occurred in the liquid phase where half of the coupons were suspended. There was no increase in corrosion rate observed at vapor / liquid interface on any of the specimens. Based on this 90 day study, all specimens were less than 0.70 mpy corrosion rate with half the coupon below surface. Mild carbon steel (C-1018) gave the highest corrosion rate at 0.14 mpy at 20° C and 0.65 mpy at 50° C. All remaining specimens were under 0.10 mpy. ICP analysis of GeoBrom® HG520 samples refl ect elevated iron and chromium levels at end of the 90-day period. The maximum allowable corrosion rate for each specimen with GeoBrom® HG520 depends on the application.
Revision Date: 7/20/2015
Tags: 221112 - Fossil Fuel 化石燃料, Great Lakes Solutions, Chemtura, Bromine, Corrosion, Chemicals, Mercury, Mercury Removal, Corrosion
The Hot Gas Decisions session at AFS zeroed in on key issues and options relative to selection and operation of filters and precipitators to capture a range of pollutants.
Revision Date: 4/30/2015
Tags: 221112 - Fossil Fuel 化石燃料, American Electric Power Company, Fabric Filter, Precipitator, MATS, Mercury, Regulation, USA
B&W Mitagent improves halogen use to oxidize mercury (EUEC 2015)
Summary: *Mitagent reduces injection cost for Iodine by 30‐50% while providing same 90+% Hg oxidation levels * Mitagent further improves Hg oxidation by 20‐30% for low Bromine application rates (25 ppm or less) * Mitagent reduces application rates by 30‐50% for high Bromine addition rates (>100 ppm), and therefore associated corrosion risks * Mitagent use results in significant operating cost reduction by reducing halogen usage * On going long‐term testing indicates no negative effect on boiler or AQCS performance
Revision Date: 2/25/2015
Tags: 221118 - Other Electric Power , Babcock & Wilcox, Bromide, Halogen, Mercury, Chemicals, Mercury Removal
Successful mercury reduction in pilot study at Seminole (Golder presentation at EUEC)
Summary: Pilot testing successfully reduced effluent Mercury concentrations to < 225 ng/l. Pilot influent concentrations were lower than historical maximums. Pilot test process reduced effluent Mercury to < 40 ng/l after flocculation and settling unit operations were improved. Results obtained in October 2014 (higher effluent Mercury) need further review (ratio of organosulfide:ferric iron may be a key). Substantial colloidal fraction of Mercury was present. Effective chemical addition, flocculation and settling are necessary so that sand filters (current Seminole polishing process) can be utilized. Tighter membrane filtration might be needed.
Revision Date: 2/25/2015
Tags: Golder Associates, Sulfide, Wastewater, Mercury, Mercury Removal
Trona information.
Revision Date: 8/14/2014
Tags: 221112 - Fossil Fuel 化石燃料, NatronX Technologies, Trona, MACT, Mercury
The discussion was concentrated on solution of the hydrocarbons and organic HAPs problems associated with cement kilns. This led to a broader discussion of the catalytic filter as a way to solve the organics plus all the other air pollutants
Revision Date: 8/14/2014
Tags: 221112 - Fossil Fuel 化石燃料, Albemarle, NatronX Technologies, Combustion Components Associates, MACT, Mercury
Cylenchar additive is effective on both oxidized and elemental mercury according to SRI tests
• In a gas stream carrying a 1,000µg/M3 total mercury and at least 34µg/M3 of elemental mercury, CyCurex® was easily able to reduce the total mercury concentration by >90%, and it was able to deal with >75% of the elemental mercury within 1.1 to 2.2 seconds exposure
Revision Date: 4/21/2014
Tags: 221112 - Fossil Fuel 化石燃料, Cylenchar, Chemical, Mercury
This scrubber additive prevents re-emissions and creates solids which are easily separated from the FGD wastewater. GRE is successfully operating a system with this chemical at its Bismarck, ND plant. Addition of CaBr in the scrubber improves overall efficiency.
Revision Date: 4/8/2014
Tags: 221112 - Fossil Fuel 化石燃料, Great River Energy, Mercury, Chemical, Mercury, Wastewater Treatment, Re-Emission, Mercury Removal
Revision Date: 2/27/2014
Tags: 221112 - Fossil Fuel 化石燃料, Reaction Engineering International, Catalyst, Mercury, NOx, SO3
NOx Catalyst Performance on Mercury and SO3 Webinar - Hot Topic Hour February 27, 2014
Revision Date: 2/27/2014
Tags: 221112 - Fossil Fuel 化石燃料, Cormetech, IBIDEN Group, Reaction Engineering International, Catalyst, Mercury, NOx, SO3
Revision Date: 2/27/2014
Tags: 221112 - Fossil Fuel 化石燃料, IBIDEN Group, Catalyst, Mercury, NOx
Revision Date: 2/27/2014
Tags: 221112 - Fossil Fuel 化石燃料, Cormetech, Catalyst, Mercury, NOx
Multi Pollutant Control Webinar - Hot Topic Hour - Part 1, September 26, 2013
Revision Date: 9/26/2013
Tags: 221112 - Fossil Fuel 化石燃料, Energy & Environmental Research Center, Sargent & Lundy, Sorbent Trap, MATS, Coal, HCl, Cadmium, Selenium, Mercury, NOx, SO2, Research & Development
Revision Date: 9/26/2013
Tags: 221112 - Fossil Fuel 化石燃料, Sargent & Lundy, Mercury, NOx, SO2, Research & Development, MATS, Coal
China Can Remove Mercury at Low Cost Thanks to U.S. Developments 中国能以低成本除汞得益于美国的技术发展
In order to meet tough regulations in the U.S. technology developers have made great strides in creating low cost routes to achieve mercury removal from power plant exhausts. The cost is especially low if the plant already has a scrubber. China is installing scrubbers on nearly all its plants. As a result China can remove mercury with just a few percent increase in its air pollution control investment and operating cost. There have been some very significant recent breakthroughs which need to be communicated to the Chinese policy makers. To this end Mcilvaine conducted a webinar in Mandarin Chinese with two FGD experts . A presentation on removal technology was made by Bobby Chen of CBI Shaw. Questions and discussion was provided by Shiaw Tseng of Graymont. This presentation in Mandarin is available as a recording in the Mcilvaine Global Decisions Orchard and on Youtube.
Revision Date: 8/19/2013
Tags: 221118 - Other Electric Power , 221112 - Fossil Fuel 化石燃料, Graymont, CB&I, McIlvaine, Liquid Bromine Injection, FGD, Air Quality, Mercury, FGD, China
Gordon discussed the non thermal ZLD process.This process would seem to be ideal in conjunction with the hot catalytic filter with DSI and is therefore being displayed on the hot gas filter website
Revision Date: 8/15/2013
Tags: 221112 - Fossil Fuel 化石燃料, URS Corp., Non-Thermal, Effluent Treatment, MATS, Mercury, Arsenic, Selenium, Nitrogen, Wastewater, FGD, Zero Liquid Discharge
The CoLD Crystallization Process by William Shaw, Veolia - Hot Topic Hour August 15, 2013.
New approaches to evaporator system design, especially the recently patented CoLD® crystallization technology.
Revision Date: 8/15/2013
Tags: 221112 - Fossil Fuel 化石燃料, Veolia, Pressure Evaporation, Effluent Treatment, MATS, Mercury, Arsenic, Selenium, Nitrogen, Wastewater, FGD, Zero Liquid Discharge
FGD Wastewater Treatment Evaluation by Paul Chu, EPRI - Hot Topic Hour August 15, 2013
Paul presented the work EPRI has been doing to evaluate wastewater treatment options.
Revision Date: 8/15/2013
Tags: 221112 - Fossil Fuel 化石燃料, EPRI, Effluent Treatment, MATS, Mercury, Arsenic, Selenium, Nitrogen, Wastewater, FGD
MHI has developed low CAPEX/OPEX technology for truly achieving zero liquid discharge (ZLD) from wet FGD to meet the stringent effluent limits.
Revision Date: 8/15/2013
Tags: 221112 - Fossil Fuel 化石燃料, Advatech, Wastewater Spray Dryer, Effluent Treatment, MATS, Mercury, Arsenic, Selenium, Nitrogen, Wastewater, Zero Liquid Discharge, FGD
Control and Treatment Technology for FGD Wastewater Webinar - Hot Topic Hour August 15, 2013
There are State rules in place which are requiring significant investment in treatment.
Revision Date: 8/15/2013
Tags: 221112 - Fossil Fuel 化石燃料, URS Corp., Advatech, Veolia, EPRI, Wastewater Spray Dryer, Pressure Evaporation, Non-Thermal, MATS, Arsenic, Selenium, Nitrogen, Mercury, Effluent Treatment, Wastewater, FGD, Zero Liquid Discharge
Revision Date: 8/1/2013
Tags: 221112 - Fossil Fuel 化石燃料, CB&I, Lundberg Associates, Neumann Systems Group, Novinda, Mercury Monitor, Dry Sorbent Injection, Liquid Bromine Injection, Wet Electrostatic Precipitator, Reagent Recovery, Mercury, FGD
EMO+HL, Total MATS Compliance Solution, by Bobby I.T. Chen, CB and I - Hot Topic Hour August 1, 2013
Discussed bromine injection (EMO) as the answer for mercury reduction from plants burning the full range of fuels.
Revision Date: 8/1/2013
Tags: 221112 - Fossil Fuel 化石燃料, CB&I, Mercury Monitor, Liquid Bromine Injection, Mercury
Talked about Novinda's amended silicates is a non-carbon sorbent for capture of mercury from coal-fired power plants.
Revision Date: 8/1/2013
Tags: 221112 - Fossil Fuel 化石燃料, Novinda, Dry Sorbent Injection, Mercury
UCC Dry Sorbent Injection HCl Removal by Jon Norman, United Conveyor - Hot Topic Hour July 18, 2013
Results of HCl removal tests using Dry Sorbent Injection.
Revision Date: 7/18/2013
Tags: 221112 - Fossil Fuel 化石燃料, United Conveyor, Sodium Bicarbonate, Trona, Dry Sorbent Injection, Reagent, HCl, Air Quality, Mercury, SO2, SO3
Measurement and Control of HCl - Webinar Recording - Hot Topic Hour July 18, 2013
Revision Date: 7/18/2013
Tags: 221112 - Fossil Fuel 化石燃料, SICK MAIHAK, Solvay Chemicals, United Conveyor, NatronX Technologies, Mississippi Lime, Sodium Bicarbonate, Trona, Lime, NDIR, FTIR, TDL-IR, Dry Sorbent Injection, Reagent, HCl, MATS, Air Quality, Mercury, SO2, SO3
SOLVAir Solutions by Michael Wood, Solvay Chemicals - Hot Topic Hour July 18, 2013
Discussed the use of trona and sodium bicarbonate for HCl control.
Revision Date: 7/18/2013
Tags: 221112 - Fossil Fuel 化石燃料, Solvay Chemicals, Trona, Sodium Bicarbonate, Dry Sorbent Injection, Reagent, Air Quality, HCl, Mercury, SO2, SO3
Charles discussed Dry Sorbent Handling and Injection into the Scrubber and/or Direct into the Furnace for Hg and SO2 Removal.
Revision Date: 6/20/2013
Tags: 221112 - Fossil Fuel 化石燃料, Semi-Bulk Systems, Limestone, Activated Carbon, Mixer, Conveying, Coal, Mercury, SO2, Powder Handling
Dry Sorbent Injection and Material Handling for APC - Webinar - Hot Topic Hour June 20, 2013
Revision Date: 6/20/2013
Tags: 221112 - Fossil Fuel 化石燃料, Semi-Bulk Systems, Siemens, Nol-Tec Systems, CB&I, Babcock Power, Limestone, Activated Carbon, Fabric Filter, Conveying, Bromine, Mixing, Lime, Dry Sorbent Injection, Ammonia, Mercury, SO3, Air Quality, Coal, SO2, Powder Handling, Air Pollution Control
Delta DSI Static Mixers by Clayton Erickson, Babcock Power - Hot Topic Hour June 20, 2013
Mixing and flow modeling techniques used to improve DSI performance.
Revision Date: 6/20/2013
Tags: 221112 - Fossil Fuel 化石燃料, Babcock Power, Dry Sorbent Injection, Lime, Mixing, Ammonia, Mercury, SO3
ACI Material Handling Gen 3 by Keith Day, Nol-Tec - Hot Topic Hour June 20, 2013
Discussion of Gen 3 Material Handling for ACI systems
Revision Date: 6/20/2013
Tags: 221112 - Fossil Fuel 化石燃料, Nol-Tec Systems, Dry Sorbent Injection, Lime, Mixing, Conveying, Mercury
Jim discussed some of the critical variables affecting the performance of sorbents for control of acid gases and mercury emissions from coal-fired boilers to achieve compliance with MATS regulations.
Revision Date: 6/20/2013
Tags: 221112 - Fossil Fuel 化石燃料, Siemens, Mixer, Activated CarbonConveying, Fabric Filter, Mercury, SO2
EMO™ by Bobby I.T. Chen, CB and I - Hot Topic Hour June 20, 2013
Bobby provided the EMO™+HL, Total MATS Compliance Solution"
Revision Date: 6/20/2013
Tags: 221112 - Fossil Fuel 化石燃料, CB&I, Bromine, Activated Carbon, Dry Sorbent Injection, Air Quality, Mercury, Air Pollution Control
Environmental Energy Services, Inc. at Electric Power 2013
Revision Date: 5/24/2013
Tags: 221112 - Fossil Fuel 化石燃料, Environmental Energy Services, Inc., Wastewater Treatment Chemical, Chemical, Mercury, Combustion, Air Pollution Control, Acid Gas Removal, USA
Power Plant Automation and Control Webinar - Hot Topic Hour May 16, 2013
One of the most important issues facing all types of power plants in the future is what to do about cooling of condensed steam.
Revision Date: 5/16/2013
Tags: 221112 - Fossil Fuel 化石燃料, Combustion Technologies, EES, China Guodian, Wartsila North America, CiDRA, Power & Industrial Services, Continuous Emissions Monitor, Igniter, Flow Meter, Engine, Chemical, Boiler Efficiency, Carbon Monoxide, Mercury, Boiler Efficiency, Overfire Air, Combustion, Effluent Treatment
KLeeNscrub Mercury Precipitant by Mark Keffer, EES - Hot Topic Hour May 16, 2013
A mercury re-emission preventon chemical called KLeeNscrub was described by Mark.
Revision Date: 5/16/2013
Tags: 221112 - Fossil Fuel 化石燃料, EES, Chemical, Mercury, Effluent Treatment
Particulate and Condensable Removable Webinar - Hot Topic Hour April 25, 2013
The impact of MATS, CASPR and NAAQS on coal- and oil-fueled EGU operators relative to filterable and condensable PM.
Revision Date: 4/25/2013
Tags: 221112 - Fossil Fuel 化石燃料, Donaldson, Avogadro Environmental Corp., Envitech, TDC Filter, Wet Electrostatic Precipitator, Fabric Filter, Pleated Bags, Fabric Filter, Membrane Bag, Source Testing, Mercury, PM2.5, Condensibles
Wet ESP Polishing by Andy Olds, Envitech - Hot Topic Hour April 25, 2013
Envitech supplies scrubbers and wet precipitators to various industries.
Revision Date: 4/25/2013
Tags: 221112 - Fossil Fuel 化石燃料, Envitech, Wet Electrostatic Precipitator, PM2.5, Condensibles, Mercury
Paul and John described a unique approach to mercury control based on a sorbent polymer composite (SPC) material contained within a fixed-structure located in the gas stream.
Revision Date: 4/18/2013
Tags: 221112 - Fossil Fuel 化石燃料, W. L. Gore, Fixed Bed Adsorber, Mercury
Neil explained that combustion optimization can substantially reduce mercury at the same time it is reducing NOx and improving combustion.
Revision Date: 4/18/2013
Tags: 221112 - Fossil Fuel 化石燃料, GE, Optimization, Mercury
Mercury Control - Activated Carbon Update by Rob Nebergall, Cabot - Hot Topic Hour April 18, 2013
Rob discussed recent developments in the technology of activated carbon.
Revision Date: 4/18/2013
Tags: Cabot, Activated Carbon, Mercury
Mark reviewed the effectiveness of existing control equipment and capabilities of new equipment and technologies as they relate to control of mercury emissions.
Revision Date: 4/18/2013
Tags: 221112 - Fossil Fuel 化石燃料, Bechtel, Mercury
Mercury Measurement and Control - Part 3 Webinar - Hot Topic Hour April 18, 2013
Technology changes in mercury capture.
Revision Date: 4/18/2013
Tags: 221112 - Fossil Fuel 化石燃料, W. L. Gore, TDC Filter, Bechtel, GE, Cabot, Optimization, Fixed Bed Adsorber, Chemical Injection, Tray Tower, Activated Carbon, Mercury
Mercury Measurement & Control - Part 2 Webinar - Hot Topic Hour April 11, 2013
Technologies for mercury monitoring and control are in a state of development and change.
Revision Date: 4/11/2013
Tags: 221112 - Fossil Fuel 化石燃料, Eco-Power Solutions, Midwest Energy Emissions Corp, SICK Process Automation, Activated Carbon, Dry Sorbent Injection, Mercury Monitoring, CEMS, Mercury
Mercury Monitoring, CEM and Process Control by Dan Kietzer, Sick - Hot Topic Hour April 11, 2013
Discussion of advancements in the design and performance of mercury CEMs.
Revision Date: 4/11/2013
Tags: 221112 - Fossil Fuel 化石燃料, SICK Process Automation, CEMS, Mercury
Marc said that their mercury capture programs are used at several utilities.
Revision Date: 4/11/2013
Tags: 221112 - Fossil Fuel 化石燃料, Midwest Energy Emissions Corp, Dry Sorbent Injection, Mercury
Sanjeev presented data on all-in-one system that addresses several pollutants simultaneously.
Revision Date: 4/11/2013
Tags: 221112 - Fossil Fuel 化石燃料, Eco-Power Solutions, Activated Carbon, Mercury Monitoring, Mercury
Controlling mercury (Hg) emission from the coal combustion process is best achieved through a two-stage process
Revision Date: 3/28/2013
Tags: 221112 - Fossil Fuel 化石燃料, 327310 - Cement Manufacturing 水泥生产, Chicago Bridge & Iron, Bromine, Mercury Monitoring, Mercury
Mercury Measurement and Control - Part 1, Webinar - Hot Topic Hour March 28, 2013
MATS Compliance
Revision Date: 3/28/2013
Tags: 327310 - Cement Manufacturing 水泥生产, 221112 - Fossil Fuel 化石燃料, ADA-ES, CB&I, CleanAir Engineering, Andover Technology Partners, Activated Carbon, Sorbent Trap, Bromine, Mercury Monitoring, Mercury
Mercury Measurement and Control by Jim Staudt, Andover Technology - Hot Topic Hour March 28, 2013
Discussed the issues facing utility boilers, industrial boilers and Portland cement kilns that need to measure and control Hg emissions.
Revision Date: 3/28/2013
Tags: 221112 - Fossil Fuel 化石燃料, 327310 - Cement Manufacturing 水泥生产, Andover Technology Partners, Mercury Monitoring, Activated Carbon, Mercury
Monitoring mercury at the concentration levels specified by the new EGU MATS rules will be challenging for the cement and electrical utility industries.
Revision Date: 3/28/2013
Tags: 327310 - Cement Manufacturing 水泥生产, 221112 - Fossil Fuel 化石燃料, CleanAir Engineering, Sorbent Trap, Mercury Monitoring, Mercury
Mercury Control from Coal to Stack by Sharon Sjostrom, ADA-ES - Hot Topic Hour March 28, 2013
Sharon presented an overview of important considerations for achieving MATS compliance for mercury.
Revision Date: 3/28/2013
Tags: 221112 - Fossil Fuel 化石燃料, 327310 - Cement Manufacturing 水泥生产, ADA-ES, Activated Carbon, Mercury Monitoring, Mercury
Boiler MACT Compliance Overview by Bill Liegois, Stanley Consultants - Hot Topic Hour March 21, 2013
An overview of the engineering approach and critical considerations needed to evaluate, select and implement a solution for the Industrial Boiler MACT.
Revision Date: 3/21/2013
Tags: 221112 - Fossil Fuel 化石燃料, Stanley Consultants, Scrubber, Fabric Filter, MACT, Mercury, HCl, Cost, Combustion, Industrial Boiler
Industrial Boiler MACT Impact and Control Options Part 1 - Webinar - Hot Topic Hour March 21, 2013
Will Industrial Boiler Owners spend $5 Billion or $12 Billion to meet the New Industrial Boiler MACT?
Revision Date: 3/21/2013
Tags: 221112 - Fossil Fuel 化石燃料, URS Corp., Stanley Consultants, Scrubber, Fabric Filter, MACT, Mercury, HCl, Cost, Combustion, Industrial Boiler
An estimate of the initial capital cost of complying with the Industrial Boiler MACT for coal, biomass, liquid and process gas boilers and process heaters that will be subject to emission limits under the rule.
Revision Date: 3/21/2013
Tags: 221112 - Fossil Fuel 化石燃料, URS Corp., Scrubber, Fabric Filter, MACT, Cost, Mercury, HCl, Industrial Boiler, Combustion
Implementation of the Utility MACT Rule Webinar - Hot Topic Hour February 28, 2013
History and current status of the MACT rule.
Revision Date: 2/28/2013
Tags: 221112 - Fossil Fuel 化石燃料, Burns & McDonnell, CleanAir Engineering, Calgon Carbon, NatronX Technologies, Dry Sorbent Injection, Activated Carbon, Trona, Mercury, HCl, Mercury, PM2.5, MATS
Block discussed current MATS implementation, risks and strategic considerations.
Revision Date: 2/28/2013
Tags: 221112 - Fossil Fuel 化石燃料, Burns & McDonnell, Dry Sorbent Injection, PM2.5, HCl, MATS, Mercury
Scott discussed the beneficial effects of SCR on mercury speciation as an integral part of many utilities' mercury control strategies.
Revision Date: 11/29/2012
Tags: 221112 - Fossil Fuel 化石燃料, W. S. Hinton & Associates, Catalyst, SCR, Mercury, NOx
Balaji presented data which will be a good guide on management of catalyst to obtain the desired results.
Revision Date: 11/29/2012
Tags: 221112 - Fossil Fuel 化石燃料, Niksa Energy Associates, SCR, Catalyst, Mercury, NOx
Kyle discussed advanced catalyst.
Revision Date: 11/29/2012
Tags: 221112 - Fossil Fuel 化石燃料, Hitachi Power Systems America, SCR, Catalyst, Mercury, NOx
Catalyst Selection for NOx and Other Gases - Webinar - Hot Topic Hour November 29, 2012
NOx control, impacts on mercury removal, and SO2 oxidation. Selection of an SCR catalyst.
Revision Date: 11/29/2012
Tags: 221112 - Fossil Fuel 化石燃料, Hitachi Power Systems America, CoaLogix, Niksa Energy Associates, W. S. Hinton & Associates, SCR, Catalyst Regeneration, Catalyst, Mercury, NOx, Catalyst Maintenance
FGD Scrubber Components - Webinar - Hot Topic Hour November 8, 2012
A proven method for removing aerosols and particles down to 0.1 microns that can be installed after an FGD and a new proven technology that could replace conventional scrubbers.
Revision Date: 11/8/2012
Tags: 221112 - Fossil Fuel 化石燃料, Neumann Systems Group, Kimre, Augusta Fiberglass, FRP, Fiber, Duct, Liner, Wet FGD, NeuStream, Particulates, HCl, Mercury, Aerosol
Wet FGD technology
Revision Date: 11/8/2012
Tags: 221112 - Fossil Fuel 化石燃料, Neumann Systems Group, Wet FGD, NeuStream, Mercury, HCl
Monitoring Topics Covered in August 24 Hot Topic Hour
In the hot topic hour on August 24 Mcilvaine covered several subjects important to the monitoring industry. Debbie Fox analyzed the impact of the CSAPR vacatur. Pictures of presenters and of exhibitor stands were accompanied by discussions of process monitoring in waste to energy plants, the multi metals analyzer, the MATS condundrum, boiler combustion optimization , a rapid measurement for particles in ambient air, and protocol gases, and a new SO3 monitor
Revision Date: 8/28/2012
Tags: 221112 - Fossil Fuel 化石燃料, Pall Corporation, Institute of Clean Air Companies, AMC Power / Air Monitor Corp., Eli Lilly, Thermo Scientific, ERM, Praxair, Ormantine USA, Kiewit Power Engineers, McIlvaine, ABB, Combustion Optimization, Metal Analyzer, VOC, Protocol Gases, SO3, Regulation, Standards, Mercury, Monitoring
A new catalyst (TRAC®) which achieves the Nox reduction, minimizes SO3 creation and has substantially improved conversion of elemental mercury to an oxidized form.
Revision Date: 8/2/2012
Tags: 221112 - Fossil Fuel 化石燃料, Hitachi Power Systems America, Catalyst, Mercury
Mercury Control and Removal Status and Cost - Webinar - Hot Topic Hour August 2, 2012
Different approaches for removing mercury.
Revision Date: 8/2/2012
Tags: 221112 - Fossil Fuel 化石燃料, Chemtura, URS Corp., Albemarle, Hitachi Power Systems America, Catalyst, Membrane, Activated Carbon, Bromine, Mercury
Using a concrete-friendly activated carbon.
Revision Date: 8/2/2012
Tags: 221112 - Fossil Fuel 化石燃料, Albemarle, Activated Carbon, Mercury
Bromine-based products which are available for mercury reduction.
Revision Date: 8/2/2012
Tags: 221112 - Fossil Fuel 化石燃料, Chemtura, Bromine, Mercury
The GMCS Hg Control System by Jonas Klingspor, URS - Hot Topic Hour August 2, 2012
Development of the Gore/URS mercury control technology.
Revision Date: 8/2/2012
Tags: 221112 - Fossil Fuel 化石燃料, URS Corp., Membrane, Mercury
New Developments in Power Plant Air Pollution Control - Webinar - Hot Topic Hour July 12, 2012
Power Plant Air Pollution Control
Revision Date: 7/12/2012
Tags: 221112 - Fossil Fuel 化石燃料, Kimre, Chemtura, Linde North America, Clear Edge Filtration, Enerchem, Inc., Ozone, Bromine, Limestone, Scrubber, Filter Media, Mist Eliminator, Mercury, SO3, Particulates, SO2, NOx
Developments using bromine and other halogens to capture mercury.
Revision Date: 7/12/2012
Tags: 221112 - Fossil Fuel 化石燃料, Chemtura, Bromine, Mercury
The speakers addressed the use of dry sorbent injection to meet the new MATS and CSAPR as well as material handling issues and methods to improve the performance of and reduce the usage of sorbents.
Revision Date: 6/21/2012
Tags: 221112 - Fossil Fuel 化石燃料, Mississippi Lime, Solvay Chemicals, Southern Air Solutions, Babcock Power, Graymont, Fabric Filter, Dry Sorbent Injection, Lime, Trona, Sodium Bicarbonate, SCR, Electrostatic Precipitator, SO2, Ammonia, Mercury, HCl, SO3, Reagent Preparation, Mixing, Milling
The impact of mixing on the performance of dry sorbent injection systems.
Revision Date: 6/21/2012
Tags: 221112 - Fossil Fuel 化石燃料, Babcock Power, Lime, Dry Sorbent Injection, Mixing, Ammonia, Mercury, SO3
Key properties of hydrated lime that impact sorbent performance.
Revision Date: 6/21/2012
Tags: 221112 - Fossil Fuel 化石燃料, Graymont, Sodium Bicarbonate, Lime, Fabric Filter, Electrostatic Precipitator, Dry Sorbent Injection, Trona, HCl, Mercury, SO3, Reagent Preparation
The results of trona injection for SO2 and HCl reduction for a utility boiler with ESP, an industrial boiler with ESP and a cement kiln with FF baghouse.
Revision Date: 6/21/2012
Tags: 221112 - Fossil Fuel 化石燃料, Southern Air Solutions, Dry Sorbent Injection, Fabric Filter, Electrostatic Precipitator, Lime, Trona, SO2, Mercury, HCl, Reagent Preparation
The effect of milling sodium sorbents on their performance in removing HCl and SO2.
Revision Date: 6/21/2012
Tags: 221112 - Fossil Fuel 化石燃料, Solvay Chemicals, Sodium Bicarbonate, Lime, Dry Sorbent Injection, Trona, SO3, SO2, Mercury, HCl, Reagent Preparation, Milling
Ten Years after Dry Sorbent Injection 2012 by David Escott, FLSmidth - Hot Topic Hour June 7, 2012
David pointed out that the experience with SO3 mitigation was the foundation for DSI injection for SO2 and HCl.
Revision Date: 6/7/2012
Tags: 221112 - Fossil Fuel 化石燃料, FLSmidth, Trona, Pneumatic Conveyor, Lime, Dry Sorbent Injection, SO3, HCl, Mercury, Reagent Preparation
Marcus provided efficiency comparisons for the patented “Sorbent Enhancement Additives” technology for mercury control compared to brominated activated carbon.
Revision Date: 6/7/2012
Tags: 221112 - Fossil Fuel 化石燃料, Midwest Energy Emissions Corp, Lime, Dry Sorbent Injection, Mercury, SO3, HCl, Reagent Preparation
Discussion on technology for dry sorbent material preparation and grinding.
Revision Date: 6/7/2012
Tags: 221112 - Fossil Fuel 化石燃料, Gebr. Pfeiffer, Lime, Dry Sorbent Injection, SO3, HCl, Mercury, Grinding, Reagent Preparation
There is a great deal of activity in evaluation of dry sorbent injection to meet the new MATS and CSPR.
Revision Date: 6/7/2012
Tags: 221112 - Fossil Fuel 化石燃料, Midwest Energy Emissions Corp, Breen Energy Solutions, FLSmidth, Nalco Mobotec, Gebr. Pfeiffer, Trona, Pneumatic Conveyor, Dry Sorbent Injection, Lime, CFD, HCl, SO3, Mercury, Reagent Preparation, Grinding
Summary of the challenges facing small to medium size coal-fired power plants without SCRs and scrubbers in meeting MATS and CSAPR regulations.
Revision Date: 6/7/2012
Tags: 221112 - Fossil Fuel 化石燃料, Breen Energy Solutions, Lime, Dry Sorbent Injection, SO3, HCl, Mercury, Reagent Preparation
Lew endorsed modeling of dry sorbent injection including not just CFD but also chemical reaction modeling.
Revision Date: 6/7/2012
Tags: 221112 - Fossil Fuel 化石燃料, Nalco Mobotec, CFD, Lime, Trona, Dry Sorbent Injection, HCl, SO3, Mercury, Reagent Preparation
Activated Carbon - Status Update by Robert Nebergall, Norit - Hot Topic Hour April 12, 2012.
The supply/demand situation developing for the compliance period for both activated carbon and equipment will also be highlighted.
Revision Date: 4/12/2012
Tags: 221112 - Fossil Fuel 化石燃料, Norit, Dry Sorbent Injection, Air Quality, Mercury, Utility MACT, Air Pollution Control
Specially designed concrete-friendly, gas- phase brominated PACs are now routinely used to both provide high levels of Hg capture and allow continued use in cement.
Revision Date: 4/12/2012
Tags: 221112 - Fossil Fuel 化石燃料, Albemarle, Bromine, Dry Sorbent Injection, Mercury, Utility MACT, Air Quality, Air Pollution Control
Mercury Measurement and Control - Webinar - Hot Topic Hour April 12, 2012
Current monitoring and control of mercury from coal-fired power plants.
Revision Date: 4/12/2012
Tags: 221112 - Fossil Fuel 化石燃料, ADA-ES, Thermo Fisher, Norit, Albemarle, Shaw Group, Sampling Line, Bromine, Activated Carbon, Mercury Monitor, Dry Sorbent Injection, Air Quality, Mercury, Utility MACT, Air Pollution Control
The results of their study to reduce sample line temperatures on sample lines for Hg CEMS and updates on gas generator NIST calibration capabilities.
Revision Date: 4/12/2012
Tags: 221112 - Fossil Fuel 化石燃料, Thermo Fisher, Sampling Line, Utility MACT, Mercury, Air Quality, Air Pollution Control
EMO™ by Bobby Chen, Shaw - Hot Topic Hour April 12, 2012
Bobby described a two-stage process for controlling the mercury emission from the coal combustion process.
Revision Date: 4/12/2012
Tags: 221112 - Fossil Fuel 化石燃料, Shaw Group, Bromine, Activated Carbon, Dry Sorbent Injection, Mercury, Air Quality, Air Pollution Control
Overview of MATS for Existing & New Plants by Connie Senior, ADA - Hot Topic Hour April 12, 2012.
Connie reviewed the regulations and the ability of activated carbon to meet the requirements.
Revision Date: 4/12/2012
Tags: 221112 - Fossil Fuel 化石燃料, ADA-ES, Dry Sorbent Injection, Mercury, Utility MACT, Air Quality, Air Pollution Control
Connie discussed Low Capex Solutions for Compliance with Industrial Boiler MACT
Revision Date: 3/22/2012
Tags: 221112 - Fossil Fuel 化石燃料, ADA Environmental, Mercury, Carbon Monoxide, HCl, Particulates, Industrial Boiler MACT, Combustion
Katherine focused on some of the key aspects of EPA's Proposed Reconsideration of the Boiler MACT, including certain relevant compliance deadlines.
Revision Date: 3/22/2012
Tags: 221112 - Fossil Fuel 化石燃料, Manko, Gold, Katcher & Fox, Industrial Boiler MACT, HCl, Mercury, Carbon Monoxide, Particulates, Combustion
Third Time's the Charm? By Mack McGuffey, Troutman Sanders - Hot Topic Hour March 22, 2012
Mack reviewed the history of Industrial Boiler MACT which shows that there have been substantial changes in the proposed limits each time the proposed rule has been revised.
Revision Date: 3/22/2012
Tags: 221112 - Fossil Fuel 化石燃料, Troutman Sanders, Particulates, HCl, Mercury, Carbon Monoxide, Industrial Boiler MACT, Combustion
David discussed some compliance activities boiler operators could be doing now.
Revision Date: 3/22/2012
Tags: 221112 - Fossil Fuel 化石燃料, Technology & Market Solutions, Particulates, Carbon Monoxide, HCl, Industrial Boiler MACT, Mercury, Combustion
Industrial Boiler MACT - Impact and Control Options - Webinar - Hot Topic Hour March 22, 2012
At the March 22 Hot Topic Hour speakers helped us understand the current situation of the Industrial Boiler MACT and suggested how boiler operators might deal with the impact of the current and proposed rule.
Revision Date: 3/22/2012
Tags: 221112 - Fossil Fuel 化石燃料, ADA Environmental, Troutman Sanders, Technology & Market Solutions, Manko, Gold, Katcher & Fox, Carbon Monoxide, Industrial Boiler MACT, HCl, Mercury, Combustion
EMO™ by Bobby Chen, Shaw - Hot Topic Hour March 15, 2012
Bobby Chen presented some very up-to-date information on the control of mercury from power plants burning lignite coal using a special brominated compound.
Revision Date: 3/15/2012
Tags: 221112 - Fossil Fuel 化石燃料, Shaw Group, Chemical Injection, Air Quality, Mercury, Air Pollution Control
Mercury Measurement and Control Webinar - Hot Topic Hour March 15, 2012
Presentations about new ways to control mercury and to measure it. Sorbent traps were discussed as an alternative to CEMS. Three alternatives to activated carbon were claimed to be more cost effective.
Revision Date: 3/15/2012
Tags: 221112 - Fossil Fuel 化石燃料, CleanAir Engineering, W. L. Gore, Midwest Energy Emissions Corp, Shaw Group, Sorbent Trap, Fixed Bed Adsorber, Continuous Emissions Monitor, Chemical Injection, Air Quality, Mercury, Monitoring, Air Pollution Control
John and Jeff described a new fixed-bed sorbent technology for controlling mercury emissions from combustion applications.
Revision Date: 3/15/2012
Tags: 221112 - Fossil Fuel 化石燃料, W. L. Gore, Fixed Bed Adsorber, Mercury, Air Quality, Air Pollution Control
Marc discussed control of mercury emissions from major utility and industrial boilers utilizing patented technologies.
Revision Date: 3/15/2012
Tags: 221112 - Fossil Fuel 化石燃料, Midwest Energy Emissions Corp, Chemical Injection, Air Quality, Mercury, Air Pollution Control
Jim discussed mercury measurement, specifically continuous monitoring at very low levels using sorbent trap technology.
Revision Date: 3/15/2012
Tags: 221112 - Fossil Fuel 化石燃料, CleanAir Engineering, Sorbent Trap, Continuous Emissions Monitor, Air Quality, Mercury, Monitoring
Jim presented an overview of SO3 emission control with hydrated lime.
Revision Date: 3/8/2012
Tags: 221112 - Fossil Fuel 化石燃料, Lhoist, Direct Injection System, Lime, Mercury, SO2, SO3, HCl
Jim described the application of a liquid sodium-based reagent to reduce SO3 and mercury emissions at power plants.
Revision Date: 3/8/2012
Tags: 221112 - Fossil Fuel 化石燃料, URS Corp., Direct Injection System, Sodium Bisulfate, HCl, Mercury, SO2, SO3
Yougen discussed the interactions between SO3, HCl, HBr, PM and Trona in flue gas.
Revision Date: 3/8/2012
Tags: 221112 - Fossil Fuel 化石燃料, Solvay Chemicals, Direct Injection System, Sodium Bicarbonate, Trona, HCl, Mercury, SO2, SO3
SO3 Measurement and Control - Webinar - Hot Topic Hour March 8, 2012
The affect of SO3 in the flue gas stream, emissions from the stack, particulate emissons and removal of mercury from the flue gas with ACI.
Revision Date: 3/8/2012
Tags: 221112 - Fossil Fuel 化石燃料, URS Corp., Industrial Monitor and Control Corp, Solvay Chemicals, Thermo Fisher Scientific, Lhoist, Direct Injection System, Sodium Bisulfate, Trona, SO3 Monitoring, Sodium Bicarbonate, SO3, HCl, Mercury, SO2, Monitoring
Biography of Yougen Kong - Solvay Chemicals - Hot Topic Hour October 27, 2011
BIO
Revision Date: 10/27/2011
Tags: 221112 - Fossil Fuel 化石燃料, Solvay Chemicals, Direct Injection System, Reagent, Sodium Bicarbonate, Trona, Air Quality, SO2, SO3, HCl, Mercury
Dr. Yougen Kong, P.E., Technical Development Manager at Solvay Chemicals, Inc., discussed dry injection of Trona or sodium bicarbonate, a low-cost solution to meet the SO2 and HCl limits in CSAPR, Utility MACT and Boiler MACT. Both Trona and Sodium bicarbonate are effective in reducing SO2 and HCl. Trona is slower to react and therefore less effective on SO2 but possibly better if all you want is HCl removal. Lots of the bicarbonate will be tied up in SO2 removal. So if you want to just remove HCl Trona may be the answer.
Revision Date: 10/27/2011
Tags: 221112 - Fossil Fuel 化石燃料, Solvay Chemicals, Reagent, Trona, Sodium Bicarbonate, Direct Injection System, Air Quality, SO2, SO3, HCl, Mercury
Keith Day, United Conveyor Corporation (UCC), described the results from several recent dry sorbent injection tests for simultaneous SO2 and HCl removal. Dry injection can achieve high removal efficiencies at low cost. There is a backlog of testing but the design and construction period is less than with scrubbers. So if you need to do something in a hurry this is a good route. In fact you can start with a portable unit and then move to a permanent unit later.
Revision Date: 10/27/2011
Tags: 221112 - Fossil Fuel 化石燃料, United Conveyor, Reagent, Trona, Direct Injection System, Sodium Bicarbonate, Air Quality, SO2, SO3, HCl, Mercury
John Buschmann, Technology Manager at ALSTOM Power Inc., provided an overview of the proposed Utility MACT emission values and discussed the implications for utilities seeking compliance not only under Utility MACT but also under CSAPR and various other existing and anticipated regulations. The solution is not a one-size-fits-all approach but rather a careful balancing of combinations of AQCS technologies that make up an overall compliance plan.
Revision Date: 10/27/2011
Tags: 221112 - Fossil Fuel 化石燃料, Alstom Power, SCR, Circulating Dry Scrubber, Spray Tower, Reagent, Dry Sorbent Injection, FGD, Spray Dryer Absorber, Chemical Injection, Air Quality, SO2, SO3, HCl, Mercury
Multi-Emissions Control - Webinar - Hot Topic Hour October 27, 2011
Speakers discussed the technology and equipment available or under development that provides multi-emissions control and can be implemented by EGU operators to achieve compliance with CSAPR and MACT limits.
Revision Date: 10/27/2011
Tags: 221112 - Fossil Fuel 化石燃料, Alstom Power, United Conveyor, Solvay Chemicals, Spray Dryer Absorber, Reagent, Chemical Injection, Dry Sorbent Injection, Spray Tower, FGD, SCR, Sodium Bicarbonate, Trona, Circulating Dry Scrubber, Direct Injection System, Air Quality, SO2, SO3, HCl, Mercury
Nalco Mobotec Demonstrates Total Mercury Capture for Air and Water for Coal-Fired Power Plants
Nalco offers chemicals to solve the mercury emission problem for coal fired boilers. One chemical is designed to inject in the the boiler, another is injected in the scrubber and a third in the wastewater.
Revision Date: 8/22/2011
Tags: 221112 - Fossil Fuel 化石燃料, Nalco Mobotec, Chemical, Air Quality, Mercury, Oxidation
Ruediger Peldszus, Senior Manager for Applied Technology Advanced Intermediates at Evonik Degussa GmbH, backed up his claim that TMT 15® is a good choice for separating heavy metals from flue gas scrubber water by citing a large number of installations in coal-fired power plants and also waste incineration plants. When asked how the chemical impacted the gypsum quality, Ruediger explained that the resultant compound is very small and exits the top of the hydroclone and not with the gypsum through the bottom. TMT 15 can also prevent mercury re-emission from the scrubber but for this to be successful, the parameters must be carefully evaluated. One of the participants has a client who has been challenged to successfully use the TMT 15 to prevent re-emission
Revision Date: 6/16/2011
Tags: 221112 - Fossil Fuel 化石燃料, Evonik Degussa GmbH, Wastewater Treatment Chemical, Mercury, Toxic Metal, Wastewater Treatment
FGD Wastewater Treatment Webinar - Hot Topic Hour June 16, 2011
Speakers discussed their experience with developing, testing, designing and troubleshooting treatment technologies for FGD wastewater.
Revision Date: 6/16/2011
Tags: 221112 - Fossil Fuel 化石燃料, Brooks Rand Labs, GE Power & Water, Veolia Water Solutions & Technologies, Evonik Degussa GmbH, Infilco Degremont, Wastewater Treatment Chemical, Testing, Mercury, Toxic Metal, Wastewater Treatment
John Cochran of Ceram presented results of a mercury oxidation test program which will continue through 2013. It is a result of a new major focus on mercury in Europe. The challenge is to balance the NOx removal requirements with the goals for mercury oxidation and SO3 minimization. Results were presented for one power plant with 91 percent NOx removal and 95 percent mercury removal with a catalyst with an SO2 to SO3 conversion rate across the reactor of less than 0.5 percent.
Revision Date: 4/14/2011
Tags: 221112 - Fossil Fuel 化石燃料, Ceram Environmental, Mercury
Mike Cooper, Vice President of Technology at CoaLogix explained the beneficial and detrimental reactions which impact the catalyst ability to oxidize elemental mercury. Promoters are the catalyst, lower temperatures, halogens, and V2O5. The inhibitors are NH3, H2O and SO2. Catalyst regeneration results show beneficial impacts on Hg oxidation.
Revision Date: 4/14/2011
Tags: 221112 - Fossil Fuel 化石燃料, CoaLogix, Mercury
Karin Madsen of Haldor Topsoe discussed the effect of operating conditions and catalyst type on mercury oxidation across the SCR catalyst. Up to 90 percent mercury oxidation is achievable depending on the inlet Hg speciation and the chlorine concentration. Greater than 91 percent mercury removal is achievable using existing control devices (the combination of the SCR-FGD strategy). Adding additional HCl above a certain point does not improve oxidation. However, bromine acts differently and therefore may provide greater oxidation with increased amounts.
Revision Date: 4/14/2011
Tags: 221112 - Fossil Fuel 化石燃料, Haldor Topsoe, Mercury
NOx Catalyst Performance on Mercury and SO3 - Webinar April 14, 2011
Presenters discussed the current "state of the art" of SCR design and catalyst formulations relative to mercury oxidation and SO2 to SO3 conversion and discuss their applicability to various power plant configurations including fuel type (coal, oil and bio-fuels) and other APC equipment installed or potentially required for compliance, the catalyst’s NOx reduction capabilities, the affect on other pollutants and the key issues to be considered when selecting a catalyst.
Revision Date: 4/14/2011
Tags: 221112 - Fossil Fuel 化石燃料, Ceram Environmental, CoaLogix, Haldor Topsoe, Mercury
Improving ESP Performance Webinar - Hot Topic Hour January 20, 2010
ESP Performance Improvement can be Substantial - Hot Topic Conclusion on January 20 There has been lots of focus on replacing ESPs with baghouses to meet upcoming regulations. The speakers in the Hot Topic Hour yesterday said there is an alternative. You can upgrade existing ESPs and achieve results which may satisfy future requirements. Dr. Yougen Kong, P.E., Technical Development Manager at Solvay Chemicals, Inc., told the attendees that “there is a better alternative to SO3 for conditioning electrostatic precipitators.” Trona addition system is simple and its capital cost is much lower than that of a SO3 production and injection system. Trona is relatively inexpensive and can be injected in several places. Mick Chambers, Southern Environmental, Inc, said that you can upgrade your ESP and with halogen-based additives in the coal, you can meet the particulate and mercury regulations. He showed that the SCA of recent installations has been relatively low and yet the performance high. So the footprint of a retrofit does not have to be large. When asked about the wet ESP using a fabric for the collection plate, Mick said that it is a good option and successful on industrial boilers and process applications. We were sorry to learn that John Caine passed away in a tractor accident last September. John had represented SEI in several of our previous Hot Topic Hours and has long been a contributor to the industry. Steve Jaasund, Manager Geoenergy Division A. H. Lundberg Associates, made a case for adding a wet ESP after the FGD system to meet the upcoming MACT regulations. In the discussion period it was speculated that the new mass monitoring requirements would make it more difficult for dry ESPs to meet emission limits. The wet ESP will eliminate the exceedance spikes associated with a stand-alone dry ESP. Paul Leanza of Pollution Control Services, Inc. indicated that many utilities have the opportunity to greatly improve performance of their existing precipitators. He indicated that 50 percent of the emissions occur during rapping (rapping reentrainment). These particles are relatively large and do not cause opacity spikes proportional to the mass increase. It was speculated that with mass monitoring this phenomenon will be an unpleasant surprise. Emissions will be higher with mass monitors than they were thought to be with opacity monitors and periodic stack testing. Ron Landreth of Albemarle was pleased to find that their brominated PAC actually improves precipitator performance whereas the non-brominated PAC may add to emissions. So it is worth considering brominated PAC to capture mercury and reduce particulate. Jean Bustard of ADA-ES (ADA Environmental Solutions LLC) related experience with a proprietary conditioning chemical which has performed well and does not impact mercury capture with PAC. The company offers another approach to conditioning hot side precipitators.
Revision Date: 1/20/2011
Tags: 221112 - Fossil Fuel 化石燃料, A.H. Lundberg Associates, Southern Environmental, Pollution Control Services, Albemarle, ADA-ES, Solvay Chemicals, Dry Sorbent Injection, Electrostatic Precipitator, Mercury
A better alternative to SO3 for conditioning electrostatic precipitators. The trona addition system is simple and its capital cost is much lower than that of a SO3 production and injection system.
Revision Date: 1/20/2011
Tags: 221112 - Fossil Fuel 化石燃料, Solvay Chemicals, Dry Sorbent Injection, Mercury
ESP's and Mercury Control by Mick Chambers, Southern Environmental - Hot Topic Hour January 20, 2011
ESPs and Mercury Reduction. Upgraded ESPs and halogen-based additives are rapidly gaining commercial acceptance.
Revision Date: 1/20/2011
Tags: 221112 - Fossil Fuel 化石燃料, Southern Environmental, Electrostatic Precipitator, Mercury
Integrated Approach to Mercury Control Webinar - Hot Topic Hour April 18, 2007
On April 18, 2007 GE presented performance data on their systems approach to mercury control during a special webinar facilitated by the McIlvaine Company. Combustion optimization, particulate control and sorbent injection are utilized in a complementary manner to achieve optimum results. This one hour presentation can be seen and heard by clicking on the link below. You can fast forward and stop as well as adjusting the volume.
Revision Date: 4/18/2010
Tags: 221112 - Fossil Fuel 化石燃料, McIlvaine, GE, Sorbent Injection, Electrostatic Precipitator, Mercury, Optimization
Integrated Approach to Mercury Control for Low Sulfur Coals Webinar - Hot Topic Hour May 14, 2007
Mercury from low sulfur coal burning plants can be cost effectively reduced by utilization of combustion optimization, particulate control and sorbent injection. Sorbent usage is minimized. Experience has also been achieved with the addition of biomass to the coal. A hybrid Max 9 collector at 90 MW is operating effectively with substantial mercury reduction in a pulp mill where the fuel is 90% coal and 10% biomass. Combustion optimization is achieved with biomass as either a co-fired or reburn fuel. GE is making quotations and is prepared to deal with the stringent timelines facing utilities in many States.
Revision Date: 5/4/2007
Tags: 221112 - Fossil Fuel 化石燃料, GE, McIlvaine, Electrostatic Precipitator, Sorbent Injection, Mercury, Optimization
Integrated Approach to Mercury Control - Hot Topic Hour April 18, 2007
On April 18, 2007 GE presented performance data on their systems approach to mercury control during a special webinar facilitated by the McIlvaine Company. Combustion optimization, particulate control and sorbent injection are utilized in a complementary manner to achieve optimum results. This one hour presentation can be seen and heard by clicking on the link below. You can fast forward and stop as well as adjusting the volume.
Revision Date: 4/18/2007
Tags: 221112 - Fossil Fuel 化石燃料, McIlvaine, GE, Electrostatic Precipitator, Sorbent Injection, Air Quality, Mercury, Optimization